Author Topic: System overload on Heart Interface control panel while gen set is running  (Read 1743 times)

John Harris

  • BAC Member
  • *
  • Posts: 1
1999 Beaver Monterey, 3126b.
While generator is running, the system overload light comes on the interface control panel.
Not sure what to do !
Ideas where to start 😬
1999 Monterey  30 ft. Trinidad 3126b<br />Toad = 1999 Jeep Wrangler 2 door hardtop

Steve Huber Co-Admin

  • Administrator Group
  • *
  • Posts: 3504
  • Thanked: 2689 times
John,
First thing I would do is to try and figure out what circuit is causing the problem by turning off breakers / appliances one at a time. Do you get overload indicator when on shore power or when running on batteries?
Steve
Steve
2015-          07 Contessa Bayshore C9,  400 hp
2013-2015: 00 Marquis Tourmaline, C12, 425 hp
2005-2013: 01 Contessa Naples, 3126B, 330 hp

David T. Richelderfer

  • David, Leslie, Jasper, & JoJo
  • BAC Member
  • *
  • Posts: 1676
  • Thanked: 497 times
  • OSU, Class of 1971, RVing nearly 50 years
From the Heart Interface manual for the Freedom models 10, 15, 20, 25

Steady Overload LED - Indicates an over-temperature condition, the unit is shut down.
It will reset automatically after cooling.

Blinking Overload LED - Inverter mode- Shutdown, diagnose problem using DC Amps
bargraph. Charger mode- Excessive DC voltage ripple.
Remove loads from DC battery bank. See LED 5 in the
Troubleshooting Chart, page 34.

From page 35, LED 5 - Battery overload caused by excessively discharged
batteries. Refer to page 15

From page 15:

Charging Over-Discharged Batteries -
Charging a battery bank with a terminal
voltage of less than 8 Volts presents a special
problem for the unit. If this situation arises, the
unit will attempt to charge for 1 minute. If the
charger senses excessive ripple voltage, it will
shut down to protect itself.

To successfully charge an overdischarged battery, you must remove as
much DC load as possible and set Power
Sharing to the lowest setting.

     (And there is more to read on page 15).
2004 Beaver Marquis Sapphire

I had a dream... then I lived it!