BAC Forum

General Boards => Technical Support => Topic started by: Steve Glaser on March 17, 2024, 03:30:00 AM

Title: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Steve Glaser on March 17, 2024, 03:30:00 AM

THE SOLENOID ON THE WATER LINE IS MARKED AS 120 VOLT. THE WIRING DRAWINGS SAY 12 VOLT  . I HAVE NO VOLTAGE CHECKED BREAKER PANEL AND 12 VOLT FUSE PANEL NO PROBLEMS FOUND . I HAVE THE PUMP ON AND PLUGGED INTO SHORE POWER. I HAVE HAD ALL SYSTEMS ON FOR 5 DAYS ,NOTHING HELPS.  ANY IDEAS?

Title: Re: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Eric Maclean on March 17, 2024, 01:54:24 PM

Steve
Could you give us the make and model of the fridge?

Title: Re: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Steve Glaser on March 17, 2024, 11:17:34 PM

NORCOLD MODEL 1200LRIM

IS THERE A MICROSWITCH IN THE ICE MAKER CONNECTED TO THE BAIL THAT TURNS THE ICE MAKER OFF, TURNING THE SOLENOID OFF?

IF SO, COULD THIS BE THE PROBLEM?

Title: Re: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Eric Maclean on March 17, 2024, 11:25:54 PM

Steve
Some fridges have a separate switch inside the fridge to turn the ice maker on or off others just rely on the batch control bail in the ice receiver.
The ice maker units are usually 120 volt operated using the same power that runs the clock mechanism which contains the switching gear for the water valve and motorized tray .
On most ice maker units you can remove the front cover to access the mechanism where you can test and diagnose your problem.
The service manual for your fridge should have a troubleshooting section to help you through the diagnostics.

Title: Re: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Steve Huber Co-Admin on March 17, 2024, 11:29:06 PM

Steve,
Coach Assist has both the 1200 owners manual and the 1200 Ice maker troubleshooting guide.
Steve

Title: Re: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Eric Maclean on March 17, 2024, 11:36:17 PM

Steve
Here is a link to a service manual for your fridge
Starting on page #59 the ice maker operation and diagnosis

https://myrvworks.com/wp-content/uploads/2019/04/Norcold-Service-Manual-1200.pdf

Eric

Title: Re: 2005 SANTIUM ICE MAKER NOT MAKING ICE
Post by: Steve Glaser on March 18, 2024, 12:18:19 AM

thank you for the information . I also have a leak in the ice maker so i am going to replace the ice maker. thanks again.