« previous next »
Pages: [1]   Go Down

Author Topic: Aqua Hot not heating  (Read 6783 times)

John Bagwell

  • BAC Member
  • *
  • Posts: 63
  • Thanked: 15 times
Aqua Hot not heating
« on: October 17, 2015, 02:06:13 AM »
My Aqua Hot was doing fine this morning. Turned system off to go out for day. Now diesel will not start and electric unsure.  Control panel everything looks good, all green lights.  Any ideas need heat. 
Logged
John Bagwell
2001 Monterey 36ft.
CAT 3126B
Toad. 2020 Ford Ranger

Steve Huber

  • Administrator Group
  • *
  • Posts: 3699
  • Thanked: 1602 times
Re: Aqua Hot not heating
« Reply #1 on: October 17, 2015, 02:57:45 AM »
John,
I'd hit the reset button even thought everything looks OK on the controller.
Steve
Logged
Steve
Coachless
2015- 6/24  07 Contessa Bayshore C9,  400 hp
2013-2015: 00 Marquis Tourmaline, C12, 425 hp
2005-2013: 01 Contessa Naples, 3126B, 330 hp

John Bagwell

  • BAC Member
  • *
  • Posts: 63
  • Thanked: 15 times
Re: Aqua Hot not heating
« Reply #2 on: October 17, 2015, 04:30:23 AM »
Thanks, Steve.
Could low coolent level cause not to start?
Logged
John Bagwell
2001 Monterey 36ft.
CAT 3126B
Toad. 2020 Ford Ranger

Orman Claxton

  • Guest
Re: Aqua Hot not heating
« Reply #3 on: October 17, 2015, 05:50:04 AM »
John, Are all lights green,
Check the coolant under the Radiator cap not the tank
Logged

John Bagwell

  • BAC Member
  • *
  • Posts: 63
  • Thanked: 15 times
Re: Aqua Hot not heating
« Reply #4 on: October 17, 2015, 09:59:56 AM »
We are connected to 50 amp service, forgot to include that info.  Coolant is full, removed cap and checked.  Any other ideas, not firing off?  No faults on panel at unit. All lights look good, pushed reset button.  Thanks. 
« Last Edit: October 17, 2015, 02:31:45 PM by John Bagwell »
Logged
John Bagwell
2001 Monterey 36ft.
CAT 3126B
Toad. 2020 Ford Ranger

Steve Huber

  • Administrator Group
  • *
  • Posts: 3699
  • Thanked: 1602 times
Re: Aqua Hot not heating
« Reply #5 on: October 17, 2015, 03:11:24 PM »
John,
You said that electric was "unsure". Not clear to me what that means. Is the electric mode not heating at all or partially or? You may need to leave if on for a bit to get it to heat in the electric mode.
Thx, Steve
Logged
Steve
Coachless
2015- 6/24  07 Contessa Bayshore C9,  400 hp
2013-2015: 00 Marquis Tourmaline, C12, 425 hp
2005-2013: 01 Contessa Naples, 3126B, 330 hp

Fred Brooks

  • BAC Member
  • *
  • Posts: 1663
  • Thanked: 744 times
  • RVIA Certified Luxury Technician 49 years, Retired
Re: Aqua Hot not heating
« Reply #6 on: October 17, 2015, 03:14:51 PM »
              John,

     Not really sure what your issue is. If the coach is plugged in and the electric part is on, there is a good posibility that the aqua hot is satisfied and has no reason to turn on the diesel portion if that is what you are suggesting. If that is the case, go turn off the 120volt circuit in the bedroom and run some hot water thru the faucets and then turn on the diesel switch and thermostat to heat and turn it up to 80  degrees. If it does not turn on after a few minutes, then the issue is in the wabasto unit or the controls, (aqua stat thermostat or limit switch) If the wabasto comes on and tries to ignite and mis-fires, then the issue is one of the following :the fuel supply, nozzle, igniter, photo cell, fuel pump. Enclosed is the trouble shooting guide.
      BTW did you get the hour meter I sent you?      Regards, Fred
Logged
Fred & Cindy Brooks
2000 Marquis, Jasper
C-12 Wild Cat (U of A)
2014 Honda CRV
Proverbs 3: 5 & 6
The following users thanked this post: John Bagwell

Orman Claxton

  • Guest
Re: Aqua Hot not heating
« Reply #7 on: October 17, 2015, 05:23:36 PM »

John
#1. unplug & plug back in one of the plugs on the control box, that will sometimes tell you if the box is bad
#2 Bypass # 15 & 16  on the PC Board, that will tell you if the Thermostat is bad.
#3 try bumping the rear of the Webasto unit ( maybe a dead spot on the drive motor




Logged
The following users thanked this post: John Bagwell

Ron Baisley

  • Guest
Re: Aqua Hot not heating
« Reply #8 on: October 18, 2015, 08:18:37 AM »
Take off cover of control panel, should be 4 screws. Take a small screw driver and tighten all electrical connections. I had similar problems last year and called Aqua Hot and spoke with a tech. That cured my problems. Ron Baisley
Logged
The following users thanked this post: John Bagwell
Pages: [1]   Go Up
« previous next »