Recent Posts

91

Technical Support / Re: Hurricane Engine Heat

« Last post by Fred Brooks on November 25, 2025, 07:54:25 PM »

   Not real sure where that would be on a 98, This is what mine looks like on my 2000 Marquis under the engine hatch access between the side queen bed and the rear closet. Fred

92

Technical Support / Re: Big slide doesn't extend, leveling system inop.

« Last post by Steve Huber on November 25, 2025, 04:11:32 PM »

You need a separate PW and user name for the BAC club website since they are on separate servers. Your Forum PW and user name will not work unless you establish them on the BAC club web site
https://www.beaveramb.org/
Steve

93

Technical Support / Re: Big slide doesn't extend, leveling system inop.

« Last post by Nicholas Soldevere on November 25, 2025, 02:23:41 PM »

Nicholas
If both the chassis power and gen set power are not present check the 250 amp chassis main ANL fuse at the power distribution/isolator board you will find the schematic on page 43 of the 2003 patriot wiring diagrams found in coach assist.


Eric

Viola Eric!! Got to digging around in there yesterday after finding no 12v up at the chassis power center. I went back there and found those fuses on the ceiling and sure enough nothing getting through that 250A chassis fuse. Took the fuse out and hooked it up with a battery jumper and the thing powered up and started. Fuse is on order, should be here today.

I suspect when the ground wire to the pump solenoid let go, it took out that fuse too, which is interesting because that pump has its own fuse. Ill be checking everything today, hopefully leveling system and big slide extends and the genset starts. Ill report back.

Can anyone help me with "log in" issues?  I can get in here on this forum,  but not the BAC website and not the schematics. A bit problematic when trying to troubleshoot.

EDIT: Thanks anyway, I have today successfully gotten in there to the drawings!! I noticed the sign in calls for email address vs screen name.

94

Technical Support / Re: Hurricane Engine Heat

« Last post by Steve Huber on November 24, 2025, 05:36:37 PM »

Carl,
I initially couldn't find the seasonal valves on my 2000 Marquis either. I finally located them tucked away on the driver's side under the flooring near the bed. Had obviously been installed by someone a lot more flexible than me. In any case they were not at all obvious. Also found mine were labeled in reverse (summer was winter, etc).
Steve

95

Technical Support / Re: Hurricane Engine Heat

« Last post by Carl Boger on November 24, 2025, 03:47:39 PM »

Thanks for everyone's help.

I am going to chalk this one up to OPERATOR ERROR!

I have to have the furnace actually running for the Engine Light to illuminate!  On my coach at least the thermostat has to be on heat, the Hurricane system turned on and once its running the engine heat switch will work.  The hurricane pump will run with the pump switch turned on or off depending on the signal it get from the control board.

As for the manual valves under the bed, I may have the only coach that does not have them.  I'm not sure if a prior owner deleted them or if they were never installed.

Anyway the good news is everything is working properly again.   
Thanks again for everyone's help.

96

Technical Support / Re: Hurricane Engine Heat

« Last post by David T. Richelderfer on November 24, 2025, 10:24:30 AM »

From reading this Forum over the years, I have learned there is a circular "loop" running from the engine forward through the coach furnace (Hurricane or AquaHot) and on to the dash heat.  There are one or two manual valves in this loop located under the bed (or under the engine access door in the bedroom floor).

When the engine is running, the loop's coolant circulation is provided by the engine's water pump.  When the engine is not running, the loop's coolant circulation is provided by a pump in the coach furnace (Hurricane or AquaHot) that is activated by turning ON the Engine PreHeat switch.  I can hear the coach furnace pump start running to push coolant through the loop when I turn ON the Engine Preheat switch.

Of course, to preheat the engine, two things are needed - heat and moving that heat to the engine.  So, turning ON the coach furnace (Hurricane or AquaHot) provides the heat and turning ON the Engine Preheat switch activates the pump to move the heat down the loop to the engine.

97

Technical Support / Re: Big slide doesn't extend, leveling system inop.

« Last post by Eric Maclean Co-Admin on November 24, 2025, 12:43:21 AM »

Nicholas
If both the chassis power and gen set power are not present check the 250 amp chassis main ANL fuse at the power distribution/isolator board you will find the schematic on page 43 of the 2003 patriot wiring diagrams found in coach assist.


Eric

98

Technical Support / Re: Hurricane Engine Heat

« Last post by Carl Boger on November 23, 2025, 11:49:26 PM »

Thanks Fred and David.

On my coach the circulation pump for the hurricane only comes on when the water pump switch closest to the right is turned on.  It will start the pump whether the thermostat is turned on or off.  I have no real clue that the Engine Heat switch is actually doing.  It did light up when I would turn it to the up position, but now it doesn't.   

I had believed that it might have opened a valve in the hot water lines, loop, to help preheat the engine when it was cold. 

I am also not positive that the system was installed properly.  Really why a 12 volt on off switch for engine preheat?  Where is the switch going to and what is it turning on and off?

Usually I only need AC, but I would like everything to work as it is designed.  The heat now works after you turn on the thermostat, the Hurricane switch, and the pump switch.  The fans are controlled by a separate fan switch that has high low and off speeds.

Engine Heat is a unknown for me.  The Coach is also currently winterized so there is no water in the water heater, but the heat ex changer loop is still hooked up.   As you know space is tight and following unmarked wires is challenging.

Thanks for the help everyone, and absolutely have a great Thanksgiving! 

99

Technical Support / Re: Hurricane Engine Heat

« Last post by David T. Richelderfer on November 23, 2025, 10:27:59 PM »

In our coach, the two switches say "Diesel Burner" and "Engine PreHeat" leading to less confusion.  Carl's coach's switch simply says "Engine Heat", leading to the question of whether it needs to be ON for PRE-heating the engine or ON for heating the Hurricane's water/coolant from the engine.

BTW, we have an AquaHot, not a Hurricane, and both switches mentioned above have lights ON when switched ON.

On those rare occasions when we are "in the cold," an hour or so before starting the engine I will turn ON the AquaHot's Diesel Burner switch, then 15 minutes later turn ON the Engine PreHeat switch.  An hour lead time will warm up the engine to near 100F before starting it.

100

Technical Support / Re: Hurricane Engine Heat

« Last post by Fred Brooks on November 23, 2025, 08:26:36 PM »

   Greetings Carl,
  The way the Hurricane is engineered and Beaver installed it has a loop of engine coolant going thru the water heater that heats the hot water. This is so you have hot water on demand in transit without running your Hurricane. There is an auxiliary coolant pump supplied by Hurricane that is mounted next to the Hurricane heater that is part of that loop. Here is how that works: When you turn on the Hurricane heater and you want to pre-heat your engine because it is wintertime, you turn on the switch in the consol that says engine preheat. This activates the auxiliary coolant pump. The Hurricane heater is now heating the water heater which in turn heats the engine coolant loop inside the water heater and then sends it to the engine block and then back to the water heater. This takes usually an hour to raise the engine coolant 10 degrees but is dependent upon outside ambient temperature. Never leave that Preheat switch in the ON position once you depart and start driving. If you forget, not only is the engine getting hot from throttle demand, but the Hurricane is also heating your engine thru the coolant loop inside your water heater. Hope this helps, Fred    BTW Happy Thanksgiving!