Level jack pump

[Chuck Hurd]

200 Patriot Concord 33
Where is the pump and reservoir for the leveling system

[Carl Boger]

Behind the battery compartment and in front of the service bay.  It's kid of hidden in that space, but accessible either from underneath, or the battery side.

[Chuck Hurd]

So do you fill or add fluid from the hole that has an Allen head on it? On the side

[Eric Maclean Co-Admin]

Chuck
Many of the Magnum chassis used an RVA hydraulic leveling system
there should be a black plastic vent cap that unscrews from a brass adapter it can either be in the side of the reservoir or on top of the reservoir, on our coach it faces up on the top of the reservoir   beside the hydraulic manifold closes to the passenger side of the coach.
However it could be mounted on the side as well ,
The fact you have a pipe plug in the side of the reservoir tells me yours is likely the same as mine in the top of the reservoir.

Here is a link to an RVA pump with the vent fill plug mounted in the side of the reservoir it gives you an idea what the vent cap should look like

https://rvcomponents.visonerv.com/cgi-bin/md/M1197/s1.pl?

This is a link to the fluid level top up procedure on the RVA site

https://www.rvajack.com/RVA-Fluid-Level-Service

Hope this helps
Eric

[Chuck Hurd]

Ok thanks for the pic in that link that’s what I got but it is mounted vertically and the top is almost touching the top of the floor. I’m got to get under there and see if I can locate the fill cap ..there is a plug that you remove with a Allen wrench where the cap and filler is on the link you sent me..

[Eric Maclean Co-Admin]

Chuck
Mine is mounted vertically as well .
With a light you may be able to see the vent plug by looking from the battery bay .
As I mentioned before the vent is on the top of the reservoir where the pump motor mounts to the reservoir.

Eric

[Carl Boger]

Chuck,

Mine also has a allen head plug with out the plastic cover.  Hard to get in there,but a long thin funnel or a large syringe work for me.  I have not had to add any fluid in the last couple of years.  When it started loosing fluid I had all 3 jacks rebuilt as well as at least one new valve.  Hopefully it will be problem free for a long while.

[Chuck Hurd]

If I can fill it from there it is easy to get to I’ll just have to get a small pump and hose. I know it’s low because the alarm goes off when going down hill. Thanks for the info.

[Eric Maclean Co-Admin]

Chuck
If your going to try to fill it from the plug in the side of the reservoir take that plug out slowly to make sure it is above the fluid level or you may have a mess to clean up.

Eric