Visit our BAC Favorite Places Web Page

Author Topic: Transmission temperature dash gauge versus Aladdin temperature reading?  (Read 249 times)

Rick Vyncke

  • BAC Member
  • *
  • Posts: 57
  • Thanked: 1 times
Traveled this past week in our 2004 Beaver Marquis (42,000 lbs) towing a large boat (8,500 lbs) through the Rocky Mountains in hot and dry weather.  There are two options for viewing the Allison transmission temperature: 1)  the dash gauge indicated the temperature got up to a high of about 220.  2) The Aladdin system indicated a high of about 240.  The engine was running between 185-205.

The high temps were not sustained over a long period and were seen (as expected) when climbing mountain passes and/or descending the same.  Most posts indicate that there is nothing to worry about until 250+.  Assuming that is true I should be OK... except that's getting a bit close to the danger zone for me.

I've read numerous posts here about transmission temperatures and so I won't ask to rehash that.  My question is...  which reading do I trust?  Is the dash gauge more accurate than the Aladdin system or vice versa?  There is a 20 degree difference between the two on the high end.  I suspect I'll have to take into shop where they can test the temperatures to find out which one is accurate and which is not.  Are there different sensors for each or are they both working from the same sensor?

Thanks
Rick V
2004 Beaver Marquis, Garnet (3 slides)
43'
C12

David T. Richelderfer

  • David, Leslie & Jasper
  • BAC Member
  • *
  • Posts: 1187
  • Thanked: 333 times
  • 2004 Marquis Sapphire 45, C12 - 505 hp
David, Leslie & Jasper
Towing a 2002 black Chevy Avalanche
Using a Blackhawk Towbar & Evenbrake
RF Mogul Eagle 3 for DISH TV
Go Beavers, OSU Class of '71, Math
RVing since 1973
Constitutionalists, Golfers & Capitalists
Your luck is the residue of your management
The following users thanked this post: Rick Vyncke

Mike Shumack

  • BAC Member
  • *
  • Posts: 1422
  • Thanked: 376 times
  • Orlando, Florida
Re: Transmission temperature dash gauge versus Aladdin temperature reading?
« Reply #2 on: August 15, 2019, 10:38:10 PM »
Yes, like the other thread said, the Aladdin uses the temperature gauge built into the transmission, the dash gauge uses an aftermarket sending unit screwed into the large cooler line coming off tranny running to transmission cooler.
- Mike

'05 Beaver Patriot Thunder 525, Vicksburg, CAT C13, Allison 4000MH, HydraLift
Orlando, FL